1Instruction ManualKEEP THIS MANUAL IN THE POCKET ON HEATER FOR FUTURE REFERENCEWHENEVER MAINTENANCE ADJUSTMENT OR SERVICE IS REQUIRED.NOT FOR USE IN
10This water heater must not be installed directly on carpeting.Carpeting must be protected by metal or wood panel beneaththe appliance extending beyo
11Insulation blankets are available to the general public forexternal use on gas water heaters but are not necessary withReliance products. The purpo
12a design of louver or grille is known, it should be used incalculating the size opening required to provide the freearea specified. If the design a
13FIGURE 15.SECTION A - GALVANIZED PIPING(See Figure 15)1. Position the water heater so that the existing piping willrequire the shortest distance bet
148. After checking that all connections are tight and the drainvalve near the bottom of the water heater is closed, go to“Filling the Water Heater”.S
15shown. Clean the inside of each sweat fitting with the wirebrush as shown. Make sure you do not touch the cleanedareas, see Figure 22.
16TEMPERATURE-PRESSURE RELIEF VALVEThis heater is provided with a properly certified combinationtemperature - pressure relief valve by the manufacture
17The temperature-pressure relief valve must be manuallyoperated at least once a year. Caution should be taken toensure that (1) no one is in front o
18FIGURE 28.There must be a minimum of 6” (153 mm) clearance betweensingle wall vent pipe and any combustible material. Fill andseal any clearance be
19If a standard model is installed above 2,000 feet (610 m) orhigh altitude model is installed above 4,500 feet (1,370 m), theinput rating should be r
2SAFE INSTSAFE INSTSAFE INSTSAFE INSTSAFE INSTALLAALLAALLAALLAALLATIONTIONTIONTIONTION, USE AND SERVICE, USE AND SERVICE, USE AND SERVICE, USE AND SER
20FOR YOUR SAFETY READ BEFORE LIGHTINGWARNING: If you do not follow these instructions exactly, a fire orexplosion may result causing property damage,
21FOR YOUR SAFETY READ BEFORE LIGHTINGBEFORE LIGHTING: ENTIRE SYSTEM MUST BE FILLED WITH WATER AND AIR PURGED AT FAUCETS.WARNING: If you do not follow
22on the thermostat, read the “Temperature Regulation” sectionin this manual, see Figures 31 and 32.Never allow small children to use a hot water tap,
23c. Large amounts of hot water are used in a short time and therefill water in the tank is very cold.Moisture from the products of combustion condens
24HYDROGEN GAS: Hydrogen gas can be produced in a hotwater system that has not been used for a long period of time(generally two weeks or more). Hydr
25BURNER CLEANINGIf inspection of the burner shows that cleaning is required, turnthe gas control knob clockwise ( ) to the “OFF” position,depressing
26The water heater should be drained if being shut down duringfreezing temperatures. Also periodic draining and cleaning ofsediment from the tank may
27A. Water at the draft hood is water vapor which has condensedout of the combustion products. This is caused by a problemin the vent. Contact the g
28These guidelines should be utilized by a qualified service agent.TROUBLESHOOTING GUIDELINESTROUBLESHOOTING GUIDELINESTROUBLESHOOTING GUIDELINESTROUB
29 Key No. Part Description1 Pipe Nipple2 Burner Tube3 Burner Head4 Thermocouple5 Pilot6 Draft Hood*7 Draft Hood Brace8 Inlet Tube9 Flue Baffle As
3GENERAL SAFETYGENERAL SAFETYGENERAL SAFETYGENERAL SAFETYGENERAL SAFETY
30RESIDENTIAL GAS WARRANTYTHIS WARRANTY IS APPLICABLE TO THE ORIGINAL OWNERONLY. In accordance with the warranty terms and conditionsspecified below.
31LIMITATION ON IMPLIED WARRANTIESImplied warranties, including any warranty of merchantabilityimposed on the sale of this heater under state law are
32500 Lindahl ParkwayAshland City, TN 37015www.reliancewaterheaters.com
4SAFE INSTALLATION, USE AND SERVICE ... 2GENERAL SAFETY ...
5TYPICAL INSTTYPICAL INSTTYPICAL INSTTYPICAL INSTTYPICAL INSTALLAALLAALLAALLAALLATIONTIONTIONTIONTIONGET TO KNOW YOUR WATER HEATER - GAS MODELS* INSTA
6TYPICAL INSTTYPICAL INSTTYPICAL INSTTYPICAL INSTTYPICAL INSTALLAALLAALLAALLAALLATIONTIONTIONTIONTIONFIGURE 2. MIXING VALVE USAGEThis applianc
71. Turn “OFF” the gas supply to thewater heater.If the main gas line shut-off valveserving all gas appliances isused, also shut “OFF” the gas ateach
8MAMAMAMAMATERIALS AND BASIC TTERIALS AND BASIC TTERIALS AND BASIC TTERIALS AND BASIC TTERIALS AND BASIC TOOLS NEEDEDOOLS NEEDEDOOLS NEEDEDOOLS NEEDED
9FACTS TO CONSIDER ABOUT THE LOCATIONCarefully choose an indoor location for the new water heater,because the placement is a very important considerat
Kommentare zu diesen Handbüchern